Simulations of inertial liquid-lens coalescence with the pseudopotential lattice Boltzmann method
Abstract
The coalescence of liquid lenses is relevant in various applications, including inkjet printing and fog harvesting. However, the dynamics of liquid-lens coalescence have been relatively underexplored, particularly in the case of liquid lenses with larger contact angles. The coalescence of low-viscosity liquid lenses is numerically investigated by means of the pseudopotential multi-component lattice Boltzmann method over a wide range of contact angles. In two-dimensional simulations, numerical results on the growth of the bridge height are in quantitative agreement with experimental measurements for small contact angles. In addition, a comparison of the simulation results with a theoretical approach based on the thin-sheet equations for liquid lenses shows that these equations accurately capture the bridge-growth dynamics up to moderate contact angles. For the three-dimensional case, the growth of the bridge radius is independent of the equilibrium contact angle of the liquid lenses at the initial stage of growth. The dependency between the growth of the bridge height and the bridge radius exhibits a non-linear to linear transition.
Document Type: Original article
Cited as: Xie, Q., Harting, J. Simulations of inertial liquid-lens coalescence with the pseudopotential lattice Boltzmann method. Capillarity, 2026, 18(2): 41-49. https://doi.org/10.46690/capi.2026.02.01
DOI:
https://doi.org/10.46690/capi.2026.02.01Keywords:
Coalescence, liquid lenses, lattice Boltzmann methodReferences
Aarts, D. G. A. L., Lekkerkerker, H. N. W., Guo, H., et al. Hydrodynamics of droplet coalescence. Physical Review Letters, 2005, 95(16): 164503.
Anthony, C. R., Harris, M. T., Basaran, O. A. Initial regime of drop coalescence. Physical Review Fluids, 2020, 5(3): 033608.
Bhatnagar, P. L., Gross, E. P., Krook, M. A model for collision processes in gases. I. Small amplitude processes in charged and neutral one-component systems. Physical Review, 1954, 94(3): 511-525.
Burton, J. C., Taborek, P. Role of dimensionality and axisymmetry in fluid pinch-off and coalescence. Physical Review Letters, 2007, 98(22): 224502.
Burton, J. C., Huisman, F. M., Alison, P., et al. Experimental and numerical investigation of the equilibrium geometry of liquid lenses. Langmuir, 2010, 26(19): 15316-15324.
Cappelli, S., Xie, Q., Harting, J., et al. Dynamic wetting: status and prospective of single particle based experiments and simulations. New Biotechnology, 2015, 32(5): 420-432.
Chen, H., Chen, S., Matthaeus, W. H. Recovery of the Navier-Stokes equations using a lattice-gas Boltzmann method. Physical Review A, 1992, 45(8): R5339-R5342.
Chen, L., Kang, Q., Mu, Y., et al. A critical review of the pseudopotential multiphase lattice boltzmann model: Methods and applications. International Journal of Heat and Mass Transfer, 2014, 76: 210-236.
Duchemin, L., Eggers, J., Josserand, C. Inviscid coalescence of drops. Journal of Fluid Mechanics, 2003, 487: 167-178.
Eddi, A., Winkels, K. G., Snoeijer, J. H. Influence of droplet geometry on the coalescence of low viscosity drops. Physical Review Letters, 2013, 111(14): 144502.
Eggers, J., Fontelos, M. A. Singularities: Formation, Structure, and Propagation. Cambridge, Cambridge University Press, 2015.
Eggers, J., Lister, J. R., Stone, H. A. Coalescence of liquid drops. Journal of Fluid Mechanics, 1999, 401: 293-310.
Eggers, J., Sprittles, J. E., Snoeijer, J. H. Coalescence dynamics. Annual Review of Fluid Mechanics, 2025, 57: 61-87.
Erneux, T., Davis, S. H. Nonlinear rupture of free films. Physics of Fluids, 1993, 5(5): 1117-1122.
Eslamian, M., Soltani-Kordshuli, F. Development of multiple-droplet drop-casting method for the fabrication of coatings and thin solid films. Journal of Coatings Technology and Research, 2018, 15: 271-280.
Goff, H. D. Instability and partial coalescence in whippable dairy emulsions. Journal of Dairy Science, 1997, 80(10): 2620-2630.
Gross, M., Steinbach, I., Raabe, D., et al. Viscous coalescence of droplets: A lattice Boltzmann study. Physics of Fluids, 2013, 25(5): 052101.
Hack, M. A., Tewes, W., Xie, Q., et al. Self-similar liquid lens coalescence. Physical Review Letters, 2020, 124(19): 194502.
Hernández-Sánchez, J. F., Lubbers, L. A., Eddi, A., et al. Symmetric and asymmetric coalescence of drops on a substrate. Physical Review Letters, 2012, 109(18): 184502.
Hessling, D. Simulation of drying suspensions on porous substrates. Eindhoven, Eindhoven University of Technology, 2017.
Hopper, R. W. Coalescence of two equal cylinders: Exact results for creeping viscous plane flow driven by capillarity. Journal of the American Ceramic Society, 1984, 67(12): C-262-C-264.
Hopper, R. W. Plane Stokes flow driven by capillarity on a free surface. Journal of Fluid Mechanics, 1990, 213: 349.
Kaneelil, P. R., Pahlavan, A. A., Xue, N., et al. Three-dimensional self-similarity of coalescing viscous drops in the thin-film regime. Physical Review Letters, 2022, 129(14): 144501.
Krüger, T., Kusumaatmaja, H., Kuzmin, A., et al. The lattice Boltzmann method: Principles and Practice. Cham, Switzerland, Springer Cham, 2017.
Kumar, S., Narsimhan, G., Ramkrishna, D. Coalescence in creaming emulsions. existence of a pure coalescence zone. Industrial & Engineering Chemistry Research, 1996, 35(9): 3155-3162.
Lee, M. W., Kang, D. K., Yoon, S. S., et al. Coalescence of two drops on partially wettable substrates. Langmuir, 2012, 28(8): 3791-3798.
Lim, S. J., Choi, M. C., Weon, B. M., et al. Lattice Boltzmann simulations for water coalescence. Applied Physics Letters, 2017, 111(10): 101602.
Liu, H., Kang, Q., Leonardi, C. R., et al. Multiphase lattice Boltzmann simulations for porous media applications: A review. Computational Geosciences, 2016, 20: 777-805.
Low, T. B., List, R. Collision, coalescence and breakup of raindrops. Part I: Experimentally established coalescence efficiencies and fragment size distributions in breakup. Journal of the Atmospheric Sciences, 1982, 39(7): 1591-1606.
Narhe, R. D., Beysens, D. A., Pomeau, Y. Dynamics drying in the early-stage coalescence of droplets sitting on a plate. Europhysics Letters, 2008, 81(4): 46002.
Padhan, N. B., Pandit, R. Unveiling the spatiotemporal evolution of liquid-lens coalescence: Self-similarity, vortex quadrupoles, and turbulence in a three-phase fluid system. Physics of Fluids, 2023, 35(11): 112105.
Paulsen, J. D., Burton, J. C., Nagel, S. R. Viscous to inertial crossover in liquid drop coalescence. Physical Review Letters, 2011, 106(11): 114501.
Paulsen, J. D., Burton, J. C., Nagel, S. R., et al. The inexorable resistance of inertia determines the initial regime of drop coalescence. Proceedings of the National Academy of Sciences of the United States of America, 2012, 109(18): 6857-6861.
Paulsen, J. D. Approach and coalescence of liquid drops in air. Physical Review E, 2013, 88(6): 063010.
Perazzo, A., Tomaiuolo, G., Preziosi, V., et al. Emulsions in porous media: from single droplet behavior to applications for oil recovery. Advances in Colloid and Interface Science, 2018, 256: 305-325.
Qian, Y. H., D’Humières, D., Lallemand, P. Lattice BGK models for Navier-Stokes equation. Europhysics Letters, 1992, 17(6): 479-484.
Ravazzoli, P. D., González, A. G., Diez, J. A., et al. Buoyancy and capillary effects on floating liquid lenses. Physical Review Fluids, 2020, 5(7): 073604.
Ristenpart, W. D., McCalla, P. M., Roy, R. V., et al. Coalescence of spreading droplets on a wettable substrate. Physical Review Letters, 2006, 97(6): 064501.
Scheel, T., Xie, Q., Sega, M., et al. Viscous to inertial coalescence of liquid lenses: A lattice Boltzmann investigation. Physical Review Fluids, 2023, 8(7): 074201.
Scheid, B., van Nierop, E. A., Stone, H. A. Thermocapillary-assisted pulling of contact-free liquid films. Physics of Fluids, 2012, 24(3): 032107.
Shan, X., Chen, H. Lattice Boltzmann model for simulating flows with multiple phases and components. Physical Review E, 1993, 47(3): 1815.
Shan, X., Chen, H. Simulation of nonideal gases and liquid-gas phase transitions by the lattice Boltzmann equation. Physical Review E, 1994, 49(4): 2941.
Steinberger, M., Xie, Q., Ronsin, O. J. J., et al. Challenges and opportunities in upscaling inkjet-printing of OPV. Flexible and Printed Electronics, 2024, 9(4): 043001.
Succi, S. The Lattice Boltzmann Equation: For Fluid Dynamics and Beyond. Oxford, UK, Oxford University Press, 2001.
Thoroddsen, S. T., Qian, B., Etoh, T. G., et al. The initial coalescence of miscible drops. Physics of Fluids, 2007, 19(7): 072110.
Vinodh, R., Palanivel, T., Kalanur, S. S., et al. Recent advancements in catalyst coated membranes for water electrolysis: A critical review. Energy Advances, 2024, 3(6): 1144-1166.
Wijshoff, H. Drop dynamics in the inkjet printing process. Current Opinion in Colloid & Interface Science, 2018, 36: 20-27.
Xia, X., He, C., Zhang, P. Universality in the viscous-to-inertial coalescence of liquid droplets. Proceedings of the National Academy of Sciences of the United States of America, 2019, 116(47): 23467-23472.
Xie, Q., Du, T., Brabec, C. J., et al. Effect of particle and substrate wettability on evaporation-driven assembly of colloidal monolayers. Langmuir, 2025, 41(23): 14995-15003.
Yuan, X., Liang, H., Chai, Z., et al. Phase-field-based lattice Boltzmann model for immiscible incompressible N-phase flows. Physical Review E, 2020, 101(6): 063310.
Zhao, Y., Fan, L.-S. Multirelaxation-time interaction-potential-based lattice boltzmann model for two-phase flow. Physical Review E, 2010, 82(4): 046708.
Zheng, L., Zheng, S. Phase-field-theory-based lattice Boltzmann equation method for N immiscible incompressible fluids. Physical Review E, 2019, 99(6): 063310.
Downloads
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 Qingguang Xie, Jens Harting
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.